Difference between revisions of "Building Materials Reuse - On Site"

From Green Garage Detroit
Jump to: navigation, search
(→‎Strategy and Conceptual Design)
(→‎Strategy and Conceptual Design)
 
(101 intermediate revisions by 4 users not shown)
Line 1: Line 1:
−
<small>return to [[Living Building Design Studio]]</small>  
+
<small>return to [[Sustainable Materials Management]]</small>  
  
 
=== What is It? ===
 
=== What is It? ===
Line 19: Line 19:
 
*Reuse of any material on site is preferred unless found to be unsafe.
 
*Reuse of any material on site is preferred unless found to be unsafe.
  
−
=== Green Garage Example ===
+
=== Green Garage Use of On Site Materials ===
 
----
 
----
 +
 
===== Sustainability Goals =====
 
===== Sustainability Goals =====
 
*Reuse 90% of all non-toxic materials on site.
 
*Reuse 90% of all non-toxic materials on site.
 
*Recycle 90% of remaining 10% of materials not used on site.
 
*Recycle 90% of remaining 10% of materials not used on site.
 +
*<1% of materials to enter waste stream.
  
 
===== Strategy and Conceptual Design =====
 
===== Strategy and Conceptual Design =====
  
 
{| border="1" cellpadding="5" cellspacing="0"
 
{| border="1" cellpadding="5" cellspacing="0"
−
! Material || width="150px"|Image || Amount || Reuse || Recycle || Waste
+
! Material || Original Use || width="150px"|Image || Amount || Reuse || Recycle || Projected Waste
 
|-
 
|-
−
|Wood
+
|[http://en.wikipedia.org/wiki/Lumber Wood]
 
*2"x8"
 
*2"x8"
 
*2"x4"
 
*2"x4"
 
*1"x6"
 
*1"x6"
 +
|
 +
*Ceiling joists in warehouse
 +
*Office partitions
 +
*Flooring materials in rear loft
 
|[[Image:wood.jpg|150px]]
 
|[[Image:wood.jpg|150px]]
−
|?
+
|
 +
*2100lf
 +
*TBD
 +
*TBD
 
|
 
|
 
*Wall Studs
 
*Wall Studs
Line 42: Line 51:
 
*Furniture
 
*Furniture
 
*Features
 
*Features
−
|Sawdust (soil ph balance)
+
|
 +
*[http://www.ext.colostate.edu/pubs/garden/07235.html Sawdust soil ammendment]
 
|<1%
 
|<1%
 
|-
 
|-
−
|Gypsum Wall Board
+
|[http://en.wikipedia.org/wiki/Drywall Gypsum Wall Board]
 +
|
 +
*Ceiling throughout warehouse area
 +
*Wall covering in warehouse offices
 
|[[Image:gypsum.jpg|150px]]
 
|[[Image:gypsum.jpg|150px]]
 
|7500sq ft
 
|7500sq ft
Line 51: Line 64:
 
*Wallboard
 
*Wallboard
 
*Thermal Mass
 
*Thermal Mass
 +
*Use of gypsum as material for stucco/plaster
 
*Soil (broken)
 
*Soil (broken)
−
|Grind up and return for remanufacture as drywall
+
|
−
|?
+
*Grind up and return for remanufacture as drywall
 +
*[http://www.gypsumrecycling.us/ gypsumrecycling.us]
 +
|0%
 
|-
 
|-
−
|Fiberboard
+
|[http://en.wikipedia.org/wiki/Particle_board Particle Board]
 +
|
 +
*Sporadic Wall Covering
 +
[http://www.ecobind.com/research/Longterm_Particleboard_Emission_Decay_Study.pdf (Formaldehyde Emission Info)]
 
|[[Image:fiberboard.jpg|150px]]
 
|[[Image:fiberboard.jpg|150px]]
−
|?
+
|232sq ft
 
|
 
|
 
*Protection of walls behind bicycle racks
 
*Protection of walls behind bicycle racks
 
*Protection of lower wall in work shop
 
*Protection of lower wall in work shop
−
|?
+
*Use panels to create desks or tables for offices
−
|?
+
*Use for project boards/kiosk
 +
[http://books.google.com/books?id=jkX3OV5gX6oC&pg=PA115&lpg=PA115&dq=%22encapsulating+fiberboard+to+reduce+formaldehyde+emission%22&source=bl&ots=WjBi07zDgV&sig=8eR2uZcAjksXoDh7YgnfOYcxc48&hl=en&ei=ck2lSZKdBIzNnQf145idBQ&sa=X&oi=book_result&resnum=2&ct=result (Sealing Fiberboard VOC p.115)]
 +
|0%
 +
|0%
 
|-
 
|-
 
|Glass
 
|Glass
 +
|
 +
*Original showroom windows for historic car dealership
 +
*Glass panel office walls, currently concealed with existing office walls
 
|[[Image:glass.jpg|150px]]
 
|[[Image:glass.jpg|150px]]
−
|?
+
|412sq ft
−
|?
+
|
−
|?
+
*Relocate historic windows within building
−
|?
+
*Reuse pane glass for transom windows
 +
*Provide glass for artist etching and painting
 +
|
 +
*Grind up for remanufacture
 +
|0%
 
|-
 
|-
 
|Brick/Block
 
|Brick/Block
 +
|
 +
*Original exterior wall constructed of double width brick
 +
*Brick veneer for window infill on front of building
 +
*Cinder block infill of original window and door locations
 +
[http://carlos.engi.cf.ac.uk/db/conmas%20index/id.htm (Information Database)]
 +
 
|[[Image:block.jpg|150px]]
 
|[[Image:block.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Relocate/reuse historic brick
−
|?
+
*Breakage/mortar for garden drainage base
 +
*Solar Storage Wall
 +
*[http://www.abc.net.au/gardening/stories/s1190731.htm Garden Projects]
 +
*[http://reuseandrecycle.info/tag/recycling-bricks/ Example Article]
 +
|
 +
*[http://carlos.engi.cf.ac.uk/db/conmas%20index/richard%20worka.htm Masonry Recycling]
 +
|0%
 
|-
 
|-
−
|Concrete
+
|[http://en.wikipedia.org/wiki/Concrete Concrete]
 +
|
 +
*Additional sidewalk added between city walk and building
 
|[[Image:concrete.jpg|150px]]
 
|[[Image:concrete.jpg|150px]]
−
|?
+
|TBD
 
|
 
|
 
*Garden retaining walls
 
*Garden retaining walls
 
*Steps
 
*Steps
 
*Fill for truck ramp
 
*Fill for truck ramp
−
|?
+
*[http://www.sustainablesites.org/cases/show.php?id=17 Local Example]
 +
|
 +
*0%
 +
*[http://www.concretenetwork.com/concrete/demolition/recycling_concrete.htm Recycling Concrete]
 +
|0%
 
|-
 
|-
 
|Pipe
 
|Pipe
 +
|
 +
*Various diameter pipes used for original steam(radiator) heating system
 
|[[Image:pipe.jpg|150px]]
 
|[[Image:pipe.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Furniture
−
|?
+
*Stair rail
 +
*Bike rack
 +
*Water catch system
 +
*Aesthetically
 +
|[http://www.detroitscrapmetal.com/ Detroit Scrap Metal]
 +
|0%
 
|-
 
|-
−
|Cellulose
+
|[http://en.wikipedia.org/wiki/Cellulose_insulation Cellulose]
 +
|
 +
*Blown in cellulose located in ceiling throughout building
 
|[[Image:cellulose.jpg|150px]]
 
|[[Image:cellulose.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Relocated Insulation
−
|?
+
|
 +
*Compost
 +
*Mulch
 +
|0%
 
|-
 
|-
 
|Electrical Fixtures
 
|Electrical Fixtures
 +
|
 +
*Flourescent fixtures located in warehouse and office areas
 
|[[Image:electrical.jpg|150px]]
 
|[[Image:electrical.jpg|150px]]
−
|?
+
|74
−
|?
+
|
−
|?
+
*Relocated
−
|?
+
|0%
 +
|0%
 
|-
 
|-
 
|Fiberglass Insulation
 
|Fiberglass Insulation
 +
|
 +
*Used in exterior walls of remodeled offices
 +
*Installed under loft area at rear of warehouse
 
|[[Image:fiberglass.jpg|150px]]
 
|[[Image:fiberglass.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
Ongoing debate:
−
|?
+
*[http://www.lungusa.org/site/pp.asp?c=dvLUK9O0E&b=35439 American Lung Association]
 +
*[http://www.sustainableenterprises.com/fin/basic.htm Dangers]
 +
|No known methods
 +
|TBD
 
|-
 
|-
 
|Duct Flex/Steel
 
|Duct Flex/Steel
 +
|
 +
*Heat supplies for forced air heating system in remodeled offices
 
|[[Image:duct.jpg|150px]]
 
|[[Image:duct.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Clean and reuse in new duct work where codes allow
−
|?
+
*Bathroom ventilation
 +
*[[Earth Tubes]] manifold
 +
|
 +
*Separate components of flexible duct for recycling
 +
|0%
 +
|-
 +
|Ceiling Tiles
 +
(acoustic fiberglass)
 +
|
 +
*Suspended Ceiling
 +
*Acoustical Buffer
 +
|[[Image:ceiling.jpg|150px]]
 +
|TBD
 +
|
 +
*Encapsulate in interior walls
 +
*Kiosk Pin Board
 +
*Sound insulation
 +
|
 +
*[http://www.armstrong.com/commceilingsna/article45691.html Armstrong Recycling Program]
 +
|0%
 
|-
 
|-
 
|Carpet
 
|Carpet
 +
|
 +
*Glue down commercial grade floor covering in offices
 
|[[Image:carpet.jpg|150px]]
 
|[[Image:carpet.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Mitigate damage of temporary truck well fill
−
|?
+
|
 +
*[http://www.go-glr.com/Home.aspx?site=3 Great lakes Recycling]
 +
*[http://www.shawfloors.com/Cms/Home.aspx?DN=304350a3-77f6-4118-96db-775897b579cc&section=Recycling Shaw Industries Recycling Program]
 +
|100%
 
|-
 
|-
 
|Wiring
 
|Wiring
 +
|
 +
*Electrical and low voltage (phone) lines from offices and throughout ceiling
 
|[[Image:wire.jpg|150px]]
 
|[[Image:wire.jpg|150px]]
−
|?
+
|TBD
−
|?
+
|
−
|?
+
*Water Chain
−
|?
+
*Artistic Purposes
 +
|
 +
*[http://www.detroitscrapmetal.com/ Detroit Scrap Metal]
 +
*[http://www.handhmetals.com/ H and H Metals]
 +
(Need process verification.  Do they strip and recycle wire coatings?)
 +
|0%
 
|}
 
|}
  
−
[[Image:gg.jpg|150px]]
+
==== Development Story ====
 +
The [[Sustainable Materials Management - Development Story]] has images that document the Green Garage's processes involving materials.
 +
 
 +
[[Image:gg.jpg|right|150px]]
  
 
=== Resources ===
 
=== Resources ===
 
----
 
----
−
* Provide valuable links to help make it easier for others to pursue this pattern.
+
*[http://www.bmra.org/ Building Material Reuse Association]
  
 +
''Peggy edited this page'' :)
 
[[Category:site index]]
 
[[Category:site index]]
 
[[Category:One Earth Patterns]]
 
[[Category:One Earth Patterns]]

Latest revision as of 20:26, 7 November 2012

return to Sustainable Materials Management

What is It?

  • The reuse of building materials on site is a process to extend (potentially indefinitely) the period from cradle-to-grave for existing materials in the renovation of a building. Careful methods of deconstruction and repurposing of materials within the building are included in the process.
  • Also known as: Repurposing, New Life Reuse, and in some cases Adaptive Reuse and Up-cycling.

Why is it Important?

  • Helps to sustain the environment by avoiding landfills.
  • Historically preserves the integrity of the building by use of original materials.
  • Reduces embodied energy significantly by using materials that are already manufactured and have no need for transportation.

When to Use It?

  • When there are any number of materials available for harvest within the space.
  • Reuse of any material on site is preferred unless found to be unsafe.

Green Garage Use of On Site Materials

Sustainability Goals
  • Reuse 90% of all non-toxic materials on site.
  • Recycle 90% of remaining 10% of materials not used on site.
  • <1% of materials to enter waste stream.
Strategy and Conceptual Design
Material Original Use Image Amount Reuse Recycle Projected Waste
Wood
  • 2"x8"
  • 2"x4"
  • 1"x6"
  • Ceiling joists in warehouse
  • Office partitions
  • Flooring materials in rear loft
 Wood.jpg
  • 2100lf
  • TBD
  • TBD
  • Wall Studs
  • Flooring
  • Partitions
  • Furniture
  • Features
 <1%
Gypsum Wall Board
  • Ceiling throughout warehouse area
  • Wall covering in warehouse offices
 Gypsum.jpg 7500sq ft
  • Wallboard
  • Thermal Mass
  • Use of gypsum as material for stucco/plaster
  • Soil (broken)
 0%
Particle Board
  • Sporadic Wall Covering

(Formaldehyde Emission Info)

Fiberboard.jpg 232sq ft
  • Protection of walls behind bicycle racks
  • Protection of lower wall in work shop
  • Use panels to create desks or tables for offices
  • Use for project boards/kiosk

(Sealing Fiberboard VOC p.115)

0% 0%
Glass
  • Original showroom windows for historic car dealership
  • Glass panel office walls, currently concealed with existing office walls
 Glass.jpg 412sq ft
  • Relocate historic windows within building
  • Reuse pane glass for transom windows
  • Provide glass for artist etching and painting
  • Grind up for remanufacture
 0%
Brick/Block
  • Original exterior wall constructed of double width brick
  • Brick veneer for window infill on front of building
  • Cinder block infill of original window and door locations

(Information Database)

Block.jpg TBD 0%
Concrete
  • Additional sidewalk added between city walk and building
 Concrete.jpg TBD 0%
Pipe
  • Various diameter pipes used for original steam(radiator) heating system
 Pipe.jpg TBD
  • Furniture
  • Stair rail
  • Bike rack
  • Water catch system
  • Aesthetically
 Detroit Scrap Metal 0%
Cellulose
  • Blown in cellulose located in ceiling throughout building
 Cellulose.jpg TBD
  • Relocated Insulation
  • Compost
  • Mulch
 0%
Electrical Fixtures
  • Flourescent fixtures located in warehouse and office areas
 Electrical.jpg 74
  • Relocated
 0% 0%
Fiberglass Insulation
  • Used in exterior walls of remodeled offices
  • Installed under loft area at rear of warehouse
 Fiberglass.jpg TBD

Ongoing debate:

No known methods TBD
Duct Flex/Steel
  • Heat supplies for forced air heating system in remodeled offices
 Duct.jpg TBD
  • Clean and reuse in new duct work where codes allow
  • Bathroom ventilation
  • Earth Tubes manifold
  • Separate components of flexible duct for recycling
 0%
Ceiling Tiles

(acoustic fiberglass)

  • Suspended Ceiling
  • Acoustical Buffer
 Ceiling.jpg TBD
  • Encapsulate in interior walls
  • Kiosk Pin Board
  • Sound insulation
 0%
Carpet
  • Glue down commercial grade floor covering in offices
 Carpet.jpg TBD
  • Mitigate damage of temporary truck well fill
 100%
Wiring
  • Electrical and low voltage (phone) lines from offices and throughout ceiling
 Wire.jpg TBD
  • Water Chain
  • Artistic Purposes

(Need process verification. Do they strip and recycle wire coatings?)

0%

Development Story

The Sustainable Materials Management - Development Story has images that document the Green Garage's processes involving materials.

Gg.jpg

Resources

Peggy edited this page :)

Retrieved from "http://wiki.greengaragedetroit.com/index.php?title=Building_Materials_Reuse_-_On_Site&oldid=21021"